* LEAVE FOR HOMEOWNERNOTE: Due to ongoing research and product development, specifications, ratings and dimensions are subject to change without
10Model 500ERV®CLEAN • FRESH • AIRSPECIFICATIONSLATENT RECOVERY (MOISTURE) TRANSFER CORESModular (4 section) 2- Enthalpic, 2 Aluminum arranged for hig
11TI-1310105Model 700ERV®CLEAN • FRESH • AIRSPECIFICATIONSLATENT RECOVERY (MOISTURE) TRANSFER CORESModular (2 section) enthalpic (moisture) transfer c
12TI-1320105Model 1200ERV®CLEAN • FRESH • AIRSPECIFICATIONSLATENT RECOVERY (MOISTURE) TRANSFER CORESModular (3 section) latent recovery (moisture) tra
13Location for MountingThe HRV/ERV must be located in a conditionedspace where the surrounding air temperaturedoes not fall below 60˚F (16˚C). The uni
Outside WeatherhoodsThe weatherhoods must have built-in “bird” screen with1/4 in (63.5 mm) minimum mesh to prevent birds androdents from entering into
15Fresh Air Supply SystemThe fresh air supply ductwork from the HRV/ERV maybe directly connected to the return air duct of theforced air system. Check
16ECONOMIZER HRV/ERV FRESHAIR SUPPLYHRV/ERV UNITSTALE AIREXHAUST TO HRV/ERVSUPPLY DUCTRETURN AIR DUCT orBREATHER TFRESH AIR SUPPLYSTALE AIR EXHAUSTROO
17Various Installation TypesFigure 7ASaddle InstallationHang unit with suspended rodsand "U" channel members.Threaded rod and U channel(
18Electrical ConnectionsIt is recommended that a licensed electrician make allelectrical connections. It is very important that the unit be properly
19These models are equipped with a 3 speed control, low medium and high, as well as a lighted on/off switch and a 4 screw terminal strip.The terminal
2Table of ContentsIntroduction ... 2ERV Questions and Answers ...
20ControlAir 15OPTIONAL REMOTE CONTROLS Model 500 Only0011NEW! AIR SENTRY™ AIR QUALITY SENSORLOCATION: Kitchen, basement, work place (connect 1/unit
Operating the ControlAir 15Plugging in the HRV/ERV energizes the unit. A self testfunction will be performed every time the HRV/ERV isenergized (refe
22To select mode of operation for ControlAir 15Model 500 OnlyPress and hold the fan selection button on the Control Pad. After 5 seconds the control
It is necessary to have balanced air flows in an HRV/ERV. The volumeof air brought in from the outside must equal the volume of air exhaustedby the un
Servicing your HRV/ERV on a regular schedule willresult in optimum operating efficiencies and prolonged life of the equipment.Due to numerous applicat
25FILTERSOpen front service door to access the filterslocated in both supply and exhaust air streams.Note to remove and install filters, it may be eas
SYMPTOM CAUSE SOLUTIONPoor Air Flows Supply air feels coldDehumidistat is not OperatingHumidity Levels are too High Condensation is appearing on the w
27DEFROST DETAILST9T10T11T12T13T14T5T4T3GROUNDDOOR SWITCHWHITEWHITEBLACKBLACKHIGH VOLTAGE12V LOW VOLTAGEFIELD INSTALLEDLEGEND12V LOW VOLTAGEGRNNote:N
28FAN DEFROSTRemote SwitchingAnalogue StyleControlsWiring DiagramTEMPERATURE SENSORBLACKBLACKBLACKBLACKBLACKBLACKBLACKBLACKBLACKBLACKBLACKWHITEWHIT
29TERMINAL BLOCKBLUE1FAN MOTORCAPACITORSPURPLECarling Switch700 STYLEUNITS ONLYFAN MOTORCAPACITORSBROWNORANGEWHITEWHITEBLACKBLACKWHITEBLACKBLACKB
3ERV Questions & AnswersWhat is the difference between an HRV and an ERV?The core in an HRV (Heat Recovery Ventilator) transfers heat from one air
30COMMERCIAL LIFEBREATH®HEAT/ENERGY RECOVERY VENTILATORS• 2 Year Limited Warranty • 15 Year Aluminum Core Warranty• 5 Year Paper Core WarrantyNUTECH
511 McCormick Blvd.London, Ontario N5W 4C8Ph: (519) 457-1904Fx: (519) 457-1676Email: [email protected]Website: www.lifebreath.com
5MAKE UP HEAT REQUIREMENT at 1200 CFM (566L/s)Nominal Nominal NominalOutdoor Temp. kW Req. for kW Req. for kW Req. forC° F° 20°C (68°F) 25°C (77°F) 30
6OPTIONS99-104 Digital Electronic Timer - 20/40/60 min. (3 wire)99-105 Programmable Ventilation Controlincludes Programmable Time Clock, Dehumid
7Model 850FD/DDSPECIFICATIONSCORESModular (6 section) patented aluminum heat recovery cores arranged for highefficiency crossflow ventilation. MOTORS
8Model 700FD/DDSPECIFICATIONSCORESModular (2 section) patented aluminum heat recovery coresarranged for efficient cross-flow ventilation. MOTORSTwo PS
9SPECIFICATIONSCORESModular (3 section) patented aluminum heat recovery cores arrangedfor efficient cross-flow ventilation.MOTORSTwo PSC, 3 speed doub
Komentáře k této Příručce